翡翠管路過濾器HP3201A03AN濾芯
翡翠管路過濾器HP3201A03AN濾芯
翡翠管路過濾器HP3201A03AN濾芯
翡翠管路過濾器HP3201A03AN濾芯
根據在液壓系統中的安裝位置，液壓油濾芯分為吸油管路油濾芯、壓力管路油濾芯和回油管路油濾芯。主要適用于石油化工、油田管道過濾；加油設備、工程機械設備燃油過濾；水處理行業設備過濾；制藥及食品加工領域。
油氣分離元件是決定空壓機壓縮空氣品質的關鍵部件，高質量的油氣分離元件不僅可保證壓縮機的高效率工作，且濾芯壽命可達數千小時。從壓縮機頭出來的壓縮空氣夾帶大大小小的油滴。大油滴通過油氣分離罐時易分離，而小油滴（直徑1um以下懸浮油微粒）則必須通過油氣分離濾芯的微米及玻纖濾料層過濾。油微粒經過濾材的擴散作用，直接被濾材攔截以及慣性碰撞凝聚等機理，使壓縮空氣中的懸浮油微粒很快凝聚成大油滴，在重力作用下油集聚在油分芯底部，通過底部凹處回油管進口返回機頭潤滑油系統，從而使壓縮機排出更加純凈無油的壓縮空氣。壓縮空氣中的固體粒子經過油分芯時滯留在過濾層中，這就導致了油分芯壓差（阻力）不斷增加。隨著油分芯使用時間增長，當油分芯壓差達到0.08到0.1Mpa時，濾芯必須更換，否則增加壓縮機運行成本（耗電）。
空壓機空氣濾芯用于空壓機進氣口處，除去空氣中的固體顆粒，保證系統清潔要求，空氣過濾器是濾除空氣塵埃污物的部件，過濾后的干凈空氣進入螺桿轉子壓縮腔壓縮。因螺桿機內部間隙只允許15u以內的顆粒濾出。如果空濾芯堵塞破損，大量大于15u的顆粒物進入螺桿機內循環，不僅大大縮短機油濾芯、油細分離芯的使用壽命，還會導致大量顆粒物直接進入軸承腔，加速軸承磨損使轉子間隙增大，壓縮效率降低，甚至轉子枯燥咬死。
1.空氣過濾器濾芯每星期保養一次，擰開壓蓋螺母，取出空濾芯，用0.2-0.4Mpa的壓縮空氣，從空氣過濾器濾芯內腔向外吹除在空濾芯外表面的塵埃顆粒，用干凈的抹布將空濾殼內壁上的贓物擦干凈。回裝空氣過濾器濾芯，注意空濾芯前端部的密封圈要與空濾殼內端面貼合嚴密。柴油動力螺桿機的柴油機進氣空濾芯的保養應與空壓機空濾芯同步進行，保養方法相同。
2.空氣過濾器濾芯正常情況1000-1500小時更換一次，環境特別惡劣的使用場所，如礦山、陶瓷廠、棉紡廠等，建議每500小時更換空氣濾芯。
3.清潔或更換空濾芯時，部件是必須一一合對，嚴防異物落入進氣閥。
4.平時須經常檢查進氣伸縮管有無破損、吸扁，伸縮管與空濾進氣閥的連接口有無松動、漏氣。如發現須及時修復、更換。
三、空壓機機油濾芯
空壓機機油濾芯是濾除空壓機專用油中的金屬顆粒、雜質等，保證機油循環系統的潔凈，保護主機安全運行。 工作時間通常為1500~2000小時，可根據環境狀況調整。機油過濾器堵塞報警設定值一般為1.0-1.4bar超期使用的危害：回油量不足，導致排氣溫度過高，縮短油和油分芯使用壽命；導致主機潤滑不足，嚴重縮短。
廊坊濾圣達過濾器材有限公司的產品主要用于以下行業：
1.機械加工設備：造紙機械、礦業機械、注塑機及大型精密機械的潤滑系統和壓縮空氣的凈化，煙草加工設備及噴涂設備的粉塵回收過濾。
2.鐵路內燃機及發電機：潤滑油及機油的過濾
3.汽車發動機及工程機械：內燃機用空氣濾、機油濾、燃油濾、工程機械、船舶、載重車用各種液壓油濾、柴油濾、水濾。
Argo S2.0923-01, S2092301, Inline Filters FH51272,
FMHHD9201, FMH-HD920-1, FMHHD920-1, Mann 6250353210, 6250353210, HD920/1, HD9201, HD9201, SF Schupp HY10351
Faun Frisch 99707308859, 997-073-08859, Hydac 0110D005ON, Inline Filters FH51277, FINFH51277, FIN-FH51277
Inline Filters FH51285, FINFH51285, FIN-FH51285, Mattei CR21E20097, SF Schupp HY90111
Inline Filters FH51299, FINFH51299, FIN-FH51299, Liebherr 7405158, SF Schupp HY16151
Baldwin PT23523MPG, PT23523-MPG, Donaldson P171543, Inline Filters FH51316, FINFH51316, FIN-FH51316, SF Schupp HY12077
AC Delco PF297, Allis Chalmers 1128152, 11281524, 1128152-4, 34988, 734988, Atlas Copco 31761321, 3176-1321, Baldwin PT84910, PT849-10, Case IHC
381660R91, 381660-R91, 876941C91, 876941-C91, F88379, Caterpillar 3I1374, 5J8879, Clark 207930001, 207930-001, Coopers Fiaam HEM6037, Crane 102A37, Donaldson HFP558467, P165134, P558467, P779115, Fiat 70734988, 71128152, 711281524,
Finn FFP93, Fleetguard HF6185, Fleetrite HFR86185, Ford 164471, 511063, Fram C1666, Grove 9926100471, Harnischfeger 221046Z78, Hough 207679H1,
Hyster 203136, 77658, Ingersoll Rand 51057255, Inline Filters FBW-PT84910, FFGHF6185, FFG-HF6185,
FH51329, FINFH51329, FIN-FH51329, John Deere AE25453, Kralinator L967,
Luberfiner L467, LH4914, LH4981, Mann P710, Motorcraft FH2, FH68, Purolator Facet 6694002, EP247, H20247, PM6022, Ryco R2246P, Savara 92151517, SF Schupp HY9670, Towmotor 528879, 647919, Vauxhall GM 25010590, 5579576, 5579588, 6439343, Vickers 228467, 270562, 739841, 923069, 923069KIT, OFM10, OFM100, OFM101, OFM102, Wabco VM7668, VS0577, VS577, WA7574, Wix 51467, 51471, 551471, CW467MP, Woodgate WGH6185, Yale 2191600, 621916, 62191600, 6944159, 6955159
rgo S2.0923-01, S2092301, Inline Filters FH51272,
FMHHD9201, FMH-HD920-1, FMHHD920-1, Mann 6250353210, 6250353210, HD920/1, HD9201, HD9201, SF Schupp HY10351
Faun Frisch 99707308859, 997-073-08859, Hydac 0110D005ON, Inline Filters FH51277, FINFH51277, FIN-FH51277
Inline Filters FH51285, FINFH51285, FIN-FH51285, Mattei CR21E20097, SF Schupp HY90111
Inline Filters FH51299, FINFH51299, FIN-FH51299, Liebherr 7405158, SF Schupp HY16151
Baldwin PT23523MPG, PT23523-MPG, Donaldson P171543, Inline Filters FH51316, FINFH51316, FIN-FH51316, SF Schupp HY12077
AC Delco PF297, Allis Chalmers 1128152, 11281524, 1128152-4, 34988, 734988, Atlas Copco 31761321, 3176-1321, Baldwin PT84910, PT849-10, Case IHC
381660R91, 381660-R91, 876941C91, 876941-C91, F88379, Caterpillar 3I1374, 5J8879, Clark 207930001, 207930-001, Coopers Fiaam HEM6037, Crane 102A37, Donaldson HFP558467, P165134, P558467, P779115, Fiat 70734988, 71128152, 711281524,
Finn FFP93, Fleetguard HF6185, Fleetrite HFR86185, Ford 164471, 511063, Fram C1666, Grove 9926100471, Harnischfeger 221046Z78, Hough 207679H1,
Hyster 203136, 77658, Ingersoll Rand 51057255, Inline Filters FBW-PT84910, FFGHF6185, FFG-HF6185,
FH51329, FINFH51329, FIN-FH51329, John Deere AE25453, Kralinator L967,
Luberfiner L467, LH4914, LH4981, Mann P710, Motorcraft FH2, FH68, Purolator Facet 6694002, EP247, H20247, PM6022, Ryco R2246P, Savara 92151517, SF Schupp HY9670, Towmotor 528879, 647919, Vauxhall GM 25010590,
5579576, 5579588, 6439343, Vickers 228467, 270562, 739841, 923069, 923069KIT, OFM10, OFM100, OFM101, OFM102, Wabco VM7668, VS0577, VS577, WA7574, Wix 51467, 51471, 551471, CW467MP, Woodgate WGH6185, Yale 2191600, 621916, 62191600, 6944159, 6955159
rgo S2.0923-01, S2092301, Inline Filters FH51272,
FMHHD9201, FMH-HD920-1, FMHHD920-1, Mann 6250353210, 6250353210, HD920/1, HD9201, HD9201, SF Schupp HY10351
Faun Frisch 99707308859, 997-073-08859, Hydac 0110D005ON, Inline Filters FH51277, FINFH51277, FIN-FH51277
Inline Filters FH51285, FINFH51285, FIN-FH51285, Mattei CR21E20097, SF Schupp HY90111
Inline Filters FH51299, FINFH51299, FIN-FH51299, Liebherr 7405158, SF Schupp HY16151
Baldwin PT23523MPG, PT23523-MPG, Donaldson P171543, Inline Filters FH51316, FINFH51316,濾芯 FIN-FH51316, SF Schupp HY12077
AC Delco PF297, Allis Chalmers 1128152, 11281524, 1128152-4, 34988, 734988, Atlas Copco 31761321, 3176-1321, Baldwin PT84910, PT849-10, Case IHC
381660R91, 381660-R91, 876941C91, 876941-C91, F88379, Caterpillar 3I1374, 5J8879, Clark 207930001, 207930-001, Coopers Fiaam HEM6037, Crane 102A37, Donaldson HFP558467, P165134, P558467, P779115, Fiat 70734988, 71128152, 711281524,
Finn FFP93, Fleetguard HF6185, Fleetrite HFR86185, Ford 164471, 511063, Fram C1666, Grove 9926100471, Harnischfeger 221046Z78, Hough 207679H1,
Hyster 203136, 77658, Ingersoll Rand 51057255, Inline Filters FBW-PT84910, FFGHF6185, FFG-HF6185,
FH51329, FINFH51329, FIN-FH51329, John Deere濾芯 AE25453, Kralinator L967,
Luberfiner L467, LH4914, LH4981, Mann P710, Motorcraft FH2, FH68, Purolator Facet 6694002,
EP247, H20247, PM6022, Ryco R2246P, Savara 92151517, SF Schupp HY9670, Towmotor 528879, 647919, Vauxhall GM 25010590, 5579576, 5579588, 6439343, Vickers 228467, 270562, 739841, 923069,
923069KIT, OFM10, OFM100, OFM101, OFM102, Wabco VM7668, VS0577, VS577, WA7574, Wix 51467, 51471, 551471, CW467MP, Woodgate WGH6185, Yale 2191600, 621916, 62191600, 6944159, 6955159
Baldwin PT8487, Donaldson P550698, Fleetguard HF6238, Fleetrite HFR86238, Fram C7058, Inline Filters FB47350, FBWPT8487, FBW-PT8487, Luberfiner LH5961, Nelson Winslow 83284D, Q83284, Vauxhall GM 15513845, Wix 557196, 57196
Baldwin PT9144, Inline Filters FB47459, FBWPT9144, FBW-PT9144, Schroeder 8Z10, Woodgate WGH1899
Baldwin PT9426, Donaldson P502519,濾芯 Fleetguard HF28928, Inline Filters FB47646, FBWPT9426, FBW-PT9426, Komatsu 2856217320, 285-62-17320, SF Schupp SL8260
Baldwin PT23002, Bitzer 36220106, 362201-06, FAI CF115P25NA, Filtrec DMD0015D20B, Fleetguard ST1449, Inline Filters FFGST1449, FFG-ST1449, FH50008, FH51132,
FINFH50008, FIN-FH50008, FINFH51132, FIN-FH51132, FMHHD929/5, FMH-HD929/5, FMHHD9295, FMH-HD9295, FMH-HD929-5, FMHHD929-5, Mahle Knecht 7657190, 7765.719.0,
77657190, 9640512105, PI1015MIC25, Mann 6750353120, HD929/5, HD9295, Parker PR2853, SF Schupp HY15003, Stauff SL045D20B, SL-045D20B, Woodgate WGH9938
Inline Filters FH50039, FINFH50039, FIN-FH50039, Manitou 746308, SF Schupp HY90604
Hydac 0850R020MM/-KB-SFREE, 0850R020MMKBSFREE, 0850R020ON/PO/-KB,濾芯 0850R020ONPOKB, 濾芯1278247, Inline Filters FH50131, FINFH50131, FIN-FH50131, SF Schupp HY13802
Fleetguard HF7442, Inline Filters FFGHF7442, FFG-HF7442, FH50373, FINFH50373, FIN-FH50373, FUCHPR1619, FUC-HPR1619, UCC HPR.1619, HPR122910, HPR1619
AC Delco PF342, Allis Chalmers 79170, 791702, 791707, 79174, AP Lockheed 574361, AP641, AP641A, APH3184A, FH361, LK641, Baldwin P186, Case IHC 168743R91,
168743-R91, 169743R91, 169743-R91, 3074321R91, 3074321-R91, 392426C1, 392426-C1, Chrysler Dodge 1405639, 3116654, Coopers Fiaam AZH014, G723, HEM6069, Crosland 447,
Donaldson P551221, Fiat 70079170,濾芯 70079174, Finn FFP201, Fleetguard HF6195, LF602, Fleetrite HFR86195, LFR8602, Fram C1659, Greyfriars 697P, Harmo P241, Inline Filters FBWP186,
FBW-P186, FFGHF6195, FFG-HF6195, FH50165, FINFH50165, FIN-FH50165, Kralinator L953, Leyland Daf BL 37H1434, Luberfiner LP176, Mann H914, Massey Ferguson 1019235M1, 1019235M91, 1019235-M91,
1883318M1, 1883318-M1, 1883318M91, 1883318-M91, Motorcraft FH16, Plessey 550/2/04944, 550/4/04944, 550204944, 550404944, Purolator Facet 38960, 39350, MF641A, P176, P7661, P7662, P7663, P776,
P776SERIES, PM2082, Ryco R2023P, R2075PA, Savara 92151117, Soparis CAP347, Tecfil P663, PH663, Tecnocar OP921, Vapormatic VPJ4501, Vauxhall GM 2381012,
5574746, 5574758, Wix 51430, Woodgate WGH6195, Yale 515283801, 5152838-01
濾芯Baldwin PT9361, Donaldson P550582, Inline Filters FB47613, FBWPT9361, FBWPT9361, FBW-PT9361, Napa 7456, Wix 557456, 57456, Zinga WE51810Baldwin PT9426, Donaldson P502519, Fleetguard HF28928,
Inline Filters FB47646, FBWPT9426, FBWPT9426, FBW-PT9426, Komatsu 2856217320, 285-62-17320, SF Schupp SL8260
Fleetguard HF35346, Hifi Hirschi Jura SH68172, Inline Filters FH50004, FINFH50004, FIN-FH50004, FMHHD15002, FMH-HD15002, Liebherr 10326993, 11065675, 7021891, 7021896, 7025716, 7028505, Mann HD 15
002, HD 15002, HD15002, Regel Technik 066152304PL, 066152380PL, B66152380PL, B66152410PL, DGMH3761, SF Schupp HY16260, HY16285, HY16292, HY16317
Baldwin PT23002, Bitzer 36220106, 362201-06, Donaldson P174290, FAI CF115P25NA, Filtrec DMD0015D20B, Fleetguard ST1449, Inline Filters FFGST1449, FFG-ST1449, FH50008, FH51132, FINFH50008,
FIN-FH50008, FINFH51132, FIN-FH51132, FMHHD929/5, FMH-HD929/5, FMHHD9295, FMH-HD9295, FMH-HD929-5, FMHHD929-5, Mahle Knecht 7657190, 7765.719.0, 77657190, 9640512105, PI1015MIC25, Mann 6750353120,
HD929/5, HD9295, Parker PR2853, SF Schupp HY15003, Stauff SL045D20B, SL-045D20B, Woodgate WGH9938
在線咨詢 
